Water-in-Diesel Emulsions as an Alternative Fuel for Diesel Engines. Part II: Performance of Diesel Engines Fueled with Water-in-Diesel Emulsions. A Literature Review
Abstract
This paper presents the recent advances of water-in-diesel emulsion fuel studies, especially the impact of using this emulsion fuel to the performance and emissions of diesel engine. Studies revealed that the onset and the strength of micro-explosion process give strong effect with regard to the combustion efficiency inside the combustion chamber.
Most of the researchers tested emulsions with water content of 5-40% in diesel fuel. Some studies concluded that 20% water in the emulsion fuel gives the optimum engine performance. Many researchers and experts agree that the reason why there is a slight drop in brake power and torque is the fact that water-in-diesel emulsion fuel has a lower heating value than a neat diesel fuel, thus less energy is released during combustion.
In general, the results suggest that the water emulsification has a potential to slightly improve the brake efficiency and to significantly reduce the formation of NOx, soot, hydrocarbons and PM in the diesel engine.
Some factors may affect the experimental results that need to be considered, such as the effect of volatility of the base fuel, the water content of the emulsion, emulsion stability, ambient temperature, pressure, type of surfactant and engine test conditions: engine load, speed, injection timing and compression ratio.
Downloads
References
[2]. Heywood J. B., Internal combustion engine fundamentals, McGraw-Hill, 1988.
[3]. Ganesan V., Internal Combustion Engines, Tata McGraw-Hill, NewDelhi, India, 1994.
[4]. Kannan K., Udayakumar M., NOx and HC emission control using water emulsified diesel in single cylinder diesel engine, ARPN Journal of Engineering and Applied Sciences, Vol. 4, No. 8, October 2009, ISSN 1819-6608.
[5]. Hsu B. D., Combustion of water-in-diesel emulsion in an experiment medium speed diesel engine, SAE, 860300. p. 2285- 2295.
[6]. Khan M. Y. et al., Current trends in water-in-diesel emulsion as a fuel, Hindawi Publishing Corporation The Scientific World Journal, Volume 2014, Article ID 527472, 15 pages.
[7]. Lif A., Holmberg K., Water-in-diesel emulsions and related systems, Advances in Colloid and Interface Science, 123-126, 2006, p. 231-239.
[8]. Laurier L., Schramm L., Emulsions, Foams and Suspensions: Fundamentals and Applications, Copyright@2005 Wiley-vch Verlag GmbH & Co, KGaA, Weinheim, ISBN: 3-527-30743.
[9]. Sheng H.-Z., Zhang Z.-P., Wu C.-K., Study of atomization and micro-explosion of water-in-diesel fuel emulsion droplets in spray within a high temperature, high pressure bomb, International Symposium COMODIA 90, p. 275-280, 1990.
[10]. Ebna M., Fahd A., Experimental investigation of the performance and emission characteristics of direct injection diesel engine by water emulsion diesel under varying engine load condition, Applied Energy, 102, 2013, p. 1042-1049.
[11]. Armas O. et al., Characterization of light duty Diesel engine pollutant emissions using water-emulsified fuel, Fuel, 84, 2005, p. 1011-1018.
[12]. Suresh V. et al., Emission Characteristics of Diesel Engine using Water-in-Diesel Emulsified Fuel and its CFD Analysis, International Journal of Applied Environmental Sciences, ISSN 0973-6077, Vol. 9, Number 5, 2014, p. 2739-2749.
[13]. Sadler L., The airquality impact of water-diesel emulsion fuel (WDE) and selective catalytic reduction (SCR) technologies, Mayor of London, London, UK, 2003.
[14]. Ithnin A. M. et al., Combustion performance and emission analysis of diesel engine fuelled with water-in-diesel emulsion fuel made from low-grade diesel fuel, Energy Conversion and Management, 90, 2015, p. 375-382.
[15]. Attia A. M. A., Kulchitskiy A. R., Influence of the structure of water-in-fuel emulsion on diesel engine performance, Fuel, 116, 2014, p. 703-708.
[16]. Alahmer A., Influence of using emulsified diesel fuel on the performance and pollutants emitted from diesel engine, Energy Conversion and Management, 73, 2013, p. 361-369.
[17]. Canfield C. A., Effects of diesel-water emulsion combustion on diesel engine NOx emissions [M.S. thesis], Mechanical Engineering, University of Florida, Gainesville, Fla, USA, 1999.
[18]. Ghojel J., Honnery D., Al-Khaleefi K., Performance, emissions and heat release characteristics of direct injection diesel engine operating on diesel oil emulsion, Applied Thermal Engineering, vol. 26, no. 17-18, p. 2132-2141, 2006.
[19]. Samec N., Kegl B., R. Dibble W., Numerical and experiment-tal study of water/oil emulsified fuel combustion in a diesel engine, Fuel, vol. 81, no. 16, p. 2035-2044, 2002.
[20]. Samec N., Dobovisek Z., Hribernik A., The effect of water emulsified in diesel fuel on diesel fuel on exhaust emission, Goriva i Maziva, vol. 39, p. 377-392, 2000.
[21]. Barnes A. et al., Evaluation of water-blend fuels in a city bus and an assessment of performance with emission control devices, Proceedings of the Better air Quality Motor Vehicle Control &Technology, Workshop 2000.
[22]. Ithnin A. M. et al., An overview of utilizing water-in-diesel emulsion fuel in diesel engine and its potential research study, Journal of the Energy Institute, 87, 2014, p. 273-288.
[23]. Nadeem M. et al., Diesel engine performance and emission evaluation using emulsified fuels stabilized by conventional and gemini surfactants, Fuel, 85, 2006, p. 2111-2119.
